14T H Oil Boiler Bangladesh For Building

14T H Oil Boiler Bangladesh For Building

What purpose engineered food plant 14t h boiler bangladesh for building boiler plant food purposes have what? A boiler output increase; Second energy savings; Three 1. The waste heat recovery boiler output adjusted primarily by changing the secondary air with a reasonable through-air ratio, change the air fuel change material circulation boiler, the boiler load adjustment. Increasing the load, when the load shedding to reduce the oil supply. When the load changes, due to changes in the fuel supply and the air flow rate, the share of the fuel concentration and an upper combustion furnace freeboard in the furnace vary. 2. The energy savings can be found by analyzing combustion principle, the greater the excess air ratio will be more smoke, naturally more heat. The inspection report relevant when the temperature of the exhaust gas boiler is 250 deg.] C, the excess air ratio will increase by 0.1%, the boiler operating efficiency of the gas will be reduced by 0.9%. Accordingly, in order to ensure the efficiency of the gas boiler is run, should minimize the excess air ratio of the gas boiler. In practice, the boiler should be equipped with a reasonable burner, and equipment for debugging. Fuel burner in accordance with the characteristics of the operating characteristics of the boiler, fire safety burn rate to ensure that the flame furnace, combustion of the fuel.

A rated working pressure of the 14t h boiler bangladesh for building steam pressure in the boiler should be greater than the sum of the plate for the steam production required for the pipeline resistance and operating pressure. Do not neglect the steam pipe resistance, because the higher rated steam pressure, saturated steam temperatures will also increase. Second, the boiler heating surface heating surface (heat transfer area) is an important boiler (design) parameters. Because of the large output of Boilers generally large overload capability; otherwise, output is small. Same boiler capacity, a relatively large heating area, a lower exhaust gas temperature, the higher the efficiency of the boiler, fuel combustion heat is more fully utilized, consumes less. Third, boiler blowdown boiler blowdown is clean the inside, remove the sludge, reducing the effective measures of scale. Fourth, the construction furnace boiler furnace tube diameter is also one of the very important (design) parameters. After a lot of boiler running for some time in the furnace coke, smoke pipe soot accumulated soot, black smoke even began, will be a waste of fuel. The main reason is the diameter of the furnace small, atomized oil particles had a chance to be injected into the combustion furnace wall caused by high temperature carbonization. Thus, when selecting a gas boiler furnace to select a larger diameter.

It is reported that Shandong Province to further promote the action of atmospheric pollutants governance, but also to "defend the blue sky strategy" escalating, the Shandong provincial government amended the new "Regional Air Pollutant Emission Standards" and other three local standards, as the province's mandatory local standards of environmental protection, on November 1, 2019 formally implemented.

1, to improve the standard index-related emissions, can improve the level of clean production, reduce pollutant emissions, Forced out of high-emission equipment, improve air quality. The revised standard canceled the densely populated high-polluting industries sewage privilege, the use of emissions phased strategy partition; divides a region of Shandong Province as the core focus, and general control zone, different regions perform different emission limits, based on the location of the enterprise partitioning control requirements.

2, a new round of defense blue sky "Strategy" will be ultra-low emissions standards covering all coal-fired boilers in Shandong Province, and will gradually promote the non-coal industry, requires iron and steel, coking industry emissions to meet ultra-low emission standards. Key building materials industry emissions control area cement, ceramics, lime, glass, etc. are also required to achieve ultra-low emission standards, the general control zone cement, ceramics, glass and other building materials industry emission requirements more stringent than the national standards.

3, changes in air pollutant emission standards in the current round of revisions is the biggest "air pollutant emission standards iron and steel industry." The new revised standard will help eliminate a number of small-scale, backward technology, compliance governance hopeless small-scale iron and steel enterprises, and guide the existing steel enterprises discharge standards by clean energy alternatives, etc., so as to promote Shandong Province, energy, industrial restructuring, improve the quality of atmospheric environment.

4, according to monitoring data, 2018, Shandong fine particulate matter (of PM2.5), particulate matter (of PM10), sulfur dioxide (SO2), (NO2) average concentration of nitrogen dioxide fell 14.0%, 8.5%, 33.3 %, 2.7%; the number of days of heavy pollution fell for 5 days. Wherein the fine particulate matter (of PM2.5) than the average concentration of 2013, 2015 decreased 50.0%, 35.5%.

According to the "2013 Shandong Province - 2020 air pollution control plan" in 2020, the province's basic ambient air quality standards, compared with 2010 improved by 50%. Since 2013, Shandong "broken wrist" environmental pollution, has released various standard 102.

How to choose the heat exchanger is a steam 14t h boiler bangladesh for building Shandong? To steam boiler insulation damaged condition for viewing prior to use, view of the burner, to see whether the normal operation, but also to see to make sure the valve open position is correct, to view the attachment security equipment, instrumentation equipment and devices automatic control equipment must meet the requirements. Point blast furnace steam boiler admit items are: open oil circulation pump before and after the valve, the valve open oil heating process, mediation high tank level in a reasonable position, admitted that the gas pressure before the gas burner must be burned in power scale, power supply normal.

Free Chat

About Us

Contact Us