In early 2013, fast boiler is a food processing company Luohe a 10-ton condensing 8 ton furnace steam boiler installed integrally cloud service monitoring module, by monitoring the data found in March, the maximum pressure in the boiler set small deviation, the small boiler load adjustment range, and it uses a continuous replenishment way. When such a large load changes, the burner will start and stop frequently, adversely affect the boiler. After the burner system to monitor working properly, timely communication with customers, to help customers put pressure adjusted to the maximum deviation of the normal range. Then return to the display data safe range, the maximum starting frequency is reduced to the burner 4 times / hour from 8 times / hour, reduced by the mean starting frequency of 3.7 times / hr 1 / hr reported in June. At the same time gas consumption decreased by 10% to obtain the customer's trust and recognition.
Advantages of you know that hot water boiler fast boiler below Henan small taping everyone understand the advantages of a hot water boiler, burner equipped with imported brands, high intelligence level, automatic purge command in accordance with the control panel, automatic electronic ignition, automatic lit, air oil (gas) accounted for automatic adjustment, characteristic An Kuaiping stable, easy to ignite. And there are flameout protection device to ensure safety will operate. 2, hot water boilers board computer, all of the action is stored in a wonderful smart chip, a furnace key switch, automatic automatic, constant temperature operation, the customer can be provided startup, shutdown time, set after, no responsible person on duty, convenient, save effort. 3, the outer fire tube inserted spoiler natural resistance, ease exhaust rate, to enhance heat transfer, low smoke chamber to exclude dust temperature, reducing thermal damage, save fuel. 4, the font sizes that vary depending on temperature, and easy to grasp the management status of the heating furnace system, a temperature of from 10 deg.] C to 90 deg.] C can be easily set to the automatic heating furnace or heating system for the customer to produce basic necessities, bath with boiling water. 5, control of boiler water temperature controlled circulating pump according to the start-stop, boiler water exceeds the set hot water circulation pump starting when the temperature limit is less than the lower limit set temperature of hot water circulating pump terminates. 7, with the bare metal disposed over temperature maintenance (the furnace temperature is wide, burner work done automatically terminated and beeps again over temperature maintenance time (shell furnace temperature exceeds 105 deg.] C, the secondary circuit is automatically disconnected), anti-aircraft burn less water maintenance (when the boiler water is less than the low water, the furnace terminate work to do and outgoing beeps), furnace leakage protection (technical inspection to control electrical appliances go, after the break, will automatically disconnect the power of the original) .8, superheated steam oven according Zongtisheji, no pressure in the heating furnace, the security will be no risk of .9, double insulation use high centrifugal glass wool, steel tile known as black boxes, less thermal damage, anti beautiful rust.
Two of the three types of protection devices What is the difference of fuel vapor 8 ton furnace steam boilers and boiler fuel gas steam boiler steam boiler fuel for steam boilers, steam boilers or fuel oil-fired boiler is in, no matter which argument, are refers to this kind of boiler fuel steam boiler. 1. the type of fuel steam boiler fuel steam boiler, which in general, can be divided into both established and horizontal. Vertical fuel steam boiler: the combustion engine, generally use the set in this manner, and using two-pass configuration, so that complete combustion can be performed. In addition, the use of these forms, the stability of the operation of the boiler, it is also very beneficial. The advantages of vertical steam boiler fuel, mainly for high thermal efficiency, and can reduce costs. Horizontal fuel steam boiler: the structure, using a three-pass tube pyrotechnic this configuration, pressurized combustion chamber so that combustion, thereby reducing the combustion load, and reduce exhaust gas temperature. As a result, promote energy conservation, economic performance of the boiler. Further, since the waveform of threaded pipe and furnace thermal efficiency of the boiler can be remarkably improved, and the use of time can be increased. 2. The fuel vapor pressure protection boiler controller: generally this type of high sensitivity, is mainly Zidongkongzhi or chain protection. And may be adjusted according to actual operating pressure of the boiler, so that appropriate. Flame protection: in the main burner, a flame failure protection devices. Its role is the amount of fuel steam boiler combustion is detected, when abnormal combustion, can take immediate steps to make the boiler stopped working in order to avoid some of the adverse consequences. Self-locking power failure protection: Usually burst power for this case the use of the protective device, so that when a sudden power failure, the fuel steam boilers can immediately shutdown and self-locking. Note, however, that when power is restored, the boiler will not start on its own, it must be reset after unlock, boiler to start the ignition and start working. Fuel gas steam boiler and the steam boiler distinction fuel gas steam boiler and a steam boiler, as energy saving device belong to the combustion products of carbon dioxide and water, will not pollute the environment. Oil-fired boiler and gas boiler biggest difference is the use of different fuels, gas boilers use natural gas, city gas as the fuel, light oil, heavy oil-fired boiler is used as fuel. In contrast gas boilers, boiler fuel cost is much higher than gas boilers, therefore, those commonly used in the oil-fired boiler operating conditions of enterprises do not have a gas boiler or Shiyedanwei use. The difference between the fuel and gas steam boiler steam boiler: 1, fuel different: the former light oil, heavy oil as a fuel, which uses natural gas, city gas, liquefied petroleum gas as fuel. 2, the burner different: the former use of oil burners, gas burners later use. 3, different cost: the former high cost, about 1-2 times the cost of the latter. The same point of the fuel gas steam boiler and a steam boiler: 1, the same boiler: the same tonnage same steam boiler or hot water boiler of the boiler body. 2, the same auxiliary components: in addition to the burner, auxiliary oil-fired boiler and gas boiler accessories equivalent tonnage same. 3, the same production process: The process of production and processing were carried out in accordance with the same process and production standards.
The control device talk boiler automation instruments in use in boilers, their controls automation instrument is extremely important, we are concerned that today. Evaporation of 4t / h and 4t / h boiler or less. Detecting water gauge, vapor pressure gauges, water pressure gauge, water thermometer, thermometer smoke, steam flow calculation. Oil temperature, oil pressure, oil level indication, computing fuel, furnace exit gas temperature indication. Boiler flue gas oxygen content should have, furnace pressure, economizer import and export water temperature indication. Or continuously adjusting the position feedwater automatic control, automatic adjustment of a combustion boiler burning heavy oil should be automatically adjusted, should there boiler pressure adjusted automatically. Alarm and protection. High and low water level indication and alarm, low water level limit protection, over-pressure steam indication, alarm and protection, flame protection furnace, fuel gas overpressure protection or low temperature alarm and protection. Auxiliary electrical control box, the boiler should be equipped with explosion-proof electrical control equipment. Programmable and others. Drums, Fan, and start and stop the pump interlock control program, drum, fan baffle opening damper indicated, shall be provided with explosion-gas boiler electrical control equipment.Free Chat
Copyright © 2020.Company name All rights reserved.