Steam boiler rules Henan fast boiler with small series to introduce the company's horizontal steam boiler operating procedures. First, the components of the steam boiler before oven cooking oven and check (a) and oven cooked boiler furnace must be checked in detail. Check the following items: 1, cold chain grate test more than 24 hours, cold test should meet the following requirements: (1) grate should be smooth turning chain wheel axle, found arched, two tension bolts can be tightened. (2) the active grate sprocket good occlusion. Minimum gap (3) on both sides of the active grate block with the side seal and the side seal angle not less than 6 mm. Distance (4) on both sides of both ends of the furnace grate platoon leader pin in the sprocket should be kept equal. If it is found at one end to the occurrence of side friction, long waist-hole may be a tap with a hammer, the end surfaces on both sides remains equal distance. (5) steam boiler grate rotated without jamming, deviation phenomenon, when the deviation found by the inspection hole into the rear grate tail, the tie bolt align the two bearings of the drum, deviation phenomenon can be eliminated. The boiler has ignition combustion, still need to transfer found Hearth n, just before two adjustable chain tensioning bolt shaft directly outside the furnace, but preceded align the front sprocket shaft and a gearbox connect the safety pin or bolt removed until after squaring shaft to a gearbox with a chain alignment pin or bolt after tightening, may otherwise result in misalignment with the sprocket shaft of a gearbox and mechanical damage. (B) Check broken grate furnace platoon leader pin is bent, if long waist hole in the furnace may be carried out at any time platoon leader pin alignment reload. (C) a chain grate does not allow foreign matters (such as bolts, nuts, nails and other iron) is present. (D) firing door open and flexible, easy to open and drop the shutter coal, coal gate left and right side of the grate surface distance equal to, the thickness of both sides of the seam to ensure equal furnace, as a method for reducing ranging from links available to make equal, coal shutter cover plate should cover tightly to prevent leakage into the coal, coal stuck shutter. (Five) of each grate windshield of smoke damper and damper adjustment inside the flue flexible switch. (Vi) blower, Fan, Java machine, commissioning normal water supply equipment. (Vii) manhole, hand hole is tight, attached parts fitted Ge are complete. (Viii) the furnace wall is normal, the flue is tight. (Ix) steam boiler pipes, water pipes, sewage road is complete. (J) all filled with lubricating oil in the bearing housing and oil cup. (Xi) All electrical equipment should be empty running test, inspection equipment, and other electrical lines is intact.
Heating and hot water daily is an important basis for maintaining the northern region of the normal operation of enterprises; for Legal Daily organs and units, the hot water boiler is one of the indispensable energy equipment. Currently, work is facing north Heating equipment and facilities aging, increase energy conservation and environmental protection requirements and other issues. Daily logistics-related legal person responsible for improving the overall level of heating units, and the response advocated by the national energy saving, plans to purchase energy-efficient heating boiler. Considering the increasingly stringent environmental policy, Legal Daily authorities decided to use natural gas as boiler fuel. Fast boiler for 20 years, specializing in the production brand boiler, which had been successfully assisted more than Beijing enterprises and institutions, to provide clean heating. The party technical consultant fast boiler based on actual usage Legal Daily units, providing commercial condensing units 99KW vertical 1 hot water boiler.
Improve the thermal efficiency of gas horizontal steam boiler, to reduce the scale of the heating surface regardless prevention, gas steam boiler after a long run, it will produce some more or less scale. Gas steam boiler in operation, the furnace will be a series of chemical and physical reactions, in use, will form a hard and dense scale on the heating surface, which will directly result in reduced heat transfer efficiency of the boiler; and by corrosive effects of scale, will lead to reduced water wall furnace heat absorption gas steam boilers, which reduces thermal efficiency, waste input costs. The need to clean up the scale there is little that the boiler is to make long-term stable operation down. Scale thermal conductivity of only one percent of the steel, once the heating surface fouling, so that the heat transfer will be impeded, during use in order to maintain a constant output of the boiler, it is necessary to increase the temperature of the fire side. The outlet temperature of the furnace gas steam boiler is increased during the process, so that it will lose gas steam boiler is increased, so that effective heat transfer will reduce the equipment fouling in the water wall, so it is very likely It can cause water wall tube wall temperature increases lead to burst pipes water wall. Cleaning the boiler becomes particularly important. Performing the cleaning process, you can use efficient, environmentally friendly and non-corrosive cleaning agent, so that the device will be exposed to the original metallic tube, reduced to fouling. Secondly, after ignition gas steam boiler, flue gas temperature of the furnace needed to observe changes and the main steam temperature; when the main steam pressure is on the rise, if the boiler ignition, the smoke temperature rise speed or does not rise significantly Pianman, immediately check the oil on fire the gun.
Application of electric horizontal steam boiler steam boiler in the electrical industry applications in various industries ironing washing industry: dry-cleaning machine, dryer, washing machine, dryer, ironing machine, iron, and other equipment for use. Food Machinery Industry: supporting tofu machine, steamer, pot sterilization, packaging machines, coating equipment, sealing machine, and other equipment to use. Supporting the use of fermentation tank, reactor, sandwich pot, mixer, emulsifier and other equipment: bio-chemical industry. Other industries :( oil, automobile) steam cleaning industry (hotels, dormitories, schools, mixing station) hot water supply, (bridges, railways) concrete curing, (casual beauty club) sauna, hot swap equipment.Free Chat
Copyright © 2020.Company name All rights reserved.